3D INTERNATIONAL LLC.
20724 CENTRE POINTE PARKWAY, UNIT 1
SANTA CLARITA, CA 91350
Section
I Product
Identification----------------------------------------------------------------------------------------
103 Bug
Remover (Pink Liquid, Sour Odor) 07/02/02
Section
II Hazardous Ingredients
------------------------------------------------------------------------------------
Chemical
Name: % PEL/OSHA TLV-ACGIH CAS NUMBER
Sodium Metasilicate 6 to 10 3 Mg / Cubic M 3 Mg / Cubic M 6834-92-0
2-Butoxyethanol 12 to 15 50 ppm 25 ppm 111-76-2
Sodium Hydroxide 2 to 5 2Mg / Cubic M 2 Mg / Cubic M 1310-73-2
EDTA 1 to 2 50 ppm 25 ppm 64-.02-8
Section
III Physical
Data-------------------------------------------------------------------------------------------------
Boiling
Point: >211 F Specific Gravity: 1.06 Vapor
Pressure: N/A Volatiles: 94%
Vapor
Density: N/A Solubility:
100% in water Evaporation Rate: <1.1 Appear & Odor:
See Sec.I
Section IV
Fire & Explosion Data
-------------------------------------------------------------------------------------
NFPA CODES: Health: 1 Flammability:
0 Reactivity: 0 Flash Point: None
Extinguishing
Media: Sand, dry chemicals, dry foam,
halon, and water.
Hazardous
Decomposition: N/A
Special Fire
Fighting Procedures: This product
will not burn or support combustion.
Unusual Fire
& Explosion Hazards: None
Section V
Health Hazard Data -----------------------------------------------------------------------------------------
Permissible
Exposure Level: See Section II under
PEL/OSHA
Effects of
Overexposure: (Acute & Chronic)
Eyes: Contact can cause
slight irritation of the eyes and eyelids.
Skin:
Contact of this product can cause slight irritation. There is also the
possibility of defatting
of the skin due to the removal of
the skin's natural oils.
Inhalation: Fumes are generally
considered non-toxic but can cause slight irritation of the nose,
nasal passages and lungs.
Ingestion: Can cause slight irritation of the mouth, esophagus, and stomach.
Carcinogenicity: NTP: No IARC: No OSHA:
No
Signs and
symptoms of exposure: See Health
effects (Acute & Chronic)
Medical
Conditions Aggravated by Exposure:
None known.
First Aid
Procedures:
Eyes: Flush eyes for 30 minutes with cool water. If
irritation develops consult physician.
Skin: Flush exposed area with Luke warm water. If
irritation persists consult physician
immediately.
Inhalation: Remove patient to clean
atmosphere and administer oxygen if necessary. Consult
physician immediately.
Ingestion: DO NOT INDUCE VOMITING. Have patient drink large
amounts of water or milk.
Consult physician immediately.
Primary
routes of entry: Skin, eyes and
inhalation.
Section
VI Reactivity
----------------------------------------------------------------------------------------------------
Incompatibility:
None Known
Hazardous
Decomposition: See Section IV
Hazardous
Polymerization: Will not occur
Stability: Stable
Section
VII Spill or Leak Procedures
--------------------------------------------------------------------------------
Steps to be
taken in case material is Released or Spilled: Contain spill with dikes of absorbent material such
as clay, sand or vermiculate.
Waste
disposal method: All hazardous
materials must be solidified and disposed of in an EPA Approved Class One
Facility. Contact State, Local and Federal Laws.
Section VIII
Protective Equipment to be used
----------------------------------------------------------------------
Respiratory Protection: None
Ventilation: None
Protective gloves: Wear-resistant gloves such as rubber, PVC
Eye Protection: Chemical splash goggles
Other protective equipment: None
Section IX
Special Precautions and other Comments
-------------------------------------------------------------
Other
Controls: None Known
Work
Practices: Do not mix chemicals
unless instructed by qualified personnel.
Hygienic Practices:
Safety shower should be easily
accessible.
Precautions
to be taken in Storing and Handling: Keep
this material away from high heat and observe proper housekeeping procedures.
Disclaimer
of Liability ----------------------------------------------------------------------------------------------------
The information contained herein is based on data
considered to be accurate. However, the information is provided without any
warranty, expressed or implied, regarding its correctness. The conditions or
methods of handling, storage, use and disposal of the product are beyond our
control and may be beyond our knowledge. For this and other reasons, we do not
assume responsibility and expressly disclaim liability for loss, damage or
expense arising out of or in any way connected with handling, storage, use or
disposal of this product.